Tag Archives: fixing vintage pens

When Nipples Go Bad…Section Nipples, That Is

Once in a rare while, I find that the section of a pen has lost its nipple to attach an ink sac. Sometimes, an old nipple is just too heavily damaged to patch together or seat a bladder. On the vintage Wahl fountain pen below from the 1920s, the nipple actually was still attached to the remnants of the old ink sac but cleanly detached from the section.

A piece of copper tubing has been fit into a vintage fountain pen section to serve as a nipple, to which you can attach a fresh ink sac.

A piece of copper tubing has been fit into a vintage fountain pen section to serve as a nipple, to which you can attach a fresh ink sac.

As Wahl sections from the 1920s aren’t easy replacement parts to find, I find it is best to jury rig a solution. This means it is time for a trip to McDonald’s or the local hardware store.

I have used a variety of objects such as straws (from McDonald’s) to metal pipes over the years. All it needs to be is strong enough to hold a shellacked ink sac.

In this case, the hardware store had a small copper pipe that fit perfectly. Luckily for the pen, the section hole was deep enough to accommodate the inkfeed at proper depth while allowing enough room for the  pipe to hold tight. If the feed rested above the hole, then I would have been out of luck.

To get started, use a rotary tool or hacksaw to cut the pipe to the proper length. Use said rotary tool or some heavy sand paper to smooth the newly cut piece. This keeps it from not fitting or from leaving sharp pieces to hurt the ink sac. Remember to keep the replacement nipple fairly short to avoid it coming into contact with the inner pressure bar or spring. If it is too long, it might trap the filling mechanism and not allow you to fill the pen.

Coat the outside of the tube with some rubber cement, before setting it down in the section. This will seal the microscopic gap between the section and tube if you have a good fit. Plus, rubber cement won’t harm the plastic or hard rubber. Nor will it stick so tightly that you cannot remove the new nipple for any reason.

Make sure no rubber cement is clogging the inkfeed channel, preventing you from using the pen you have worked so hard to restore.

After everything is clear, use a little more rubber cement to affix the new ink sac. As long as you keep the pen away from heat, which you should always do anyway, the rubber cement makes for a good seal for the bladder. Until orange shellac became more available to pen collectors in recent years, rubber cement had been the go-to sealant for putting on new ink sacs. As I wasn’t sure how much I could trust the shellac between metal and rubber surfaces, I went with the old standby that I knew I could trust.

Upon completing this. let everything set and dry for 24-hours. Test it with water or ink to make sure the seals are good. If the pen goes for another 24-hours on its side without any leaks in the nipple, section or sac, you are good to go.

If the sac will fill but cannot retain any fluid, then there is an air leak you will need to find and seal. It might be a well hidden hairline crack elsewhere in the section. It also could be a hole in the ink sac, which is unlikely. Mostly it will be a gap somewhere between the section and the new nipple.

Once everything is tested and holding, put the rest of the pen together as you would any other repair job.

SPECIAL REMINDER: DO NOT force a piece of metal tubing into the remaining hole. Metal tubes are stronger than old hard rubber or plastic. It will crack your remaining part if forced into place.. If that happens, it is time to find a new pen to work on. Be careful.

Pen Tip #2: I Flushed My Pen. So Why Am I Still Getting Ink on My Hands?

A Q-tip can be one of your best tools for helping to clean out a pen cap and keeping your fingers from getting inky. Even after rinsing this Sheaffer Lifetime cap, you can still see plenty of ink on the cotton.

A Q-tip can be one of your best tools for helping to clean out a pen cap and keeping your fingers from getting inky. Even after rinsing this Sheaffer Lifetime cap, you can still see plenty of ink on the cotton.

Periodically flushing your pen with water often helps eliminate leaks as well as helping to get your nib to start writing well, again, as we discussed in Pen Tip #1.

Nevertheless, after you’ve gotten your pen cleaned and filled, you notice that you still have a little or a lot of ink on your fingers the next morning after you’ve decided to write with it.

The trouble often comes from old ink still inside your cap. Even if you rinsed your cap when you flushed your pen, that is not usually nearly enough to get all the old ink out.

Inside the caps of nearly all vintage and modern pens is an inner cap. It usually seals the nib compartment of your cap when the section (writing grip) of your pen screws up and against it. This keeps your pen from drying out. However, as fountain pens are wont to occasionally leak, drip or see some evaporation with heat, ink gets into these inner caps. Worse, it gets between your inner cap and outer cap shell. Once enough accumulates, your fingers are bound to get inked.

Your best bet is to soak your cap overnight in room temperature water.

Are you sensing a theme? Room temperature water and soakings are our friend.

Make sure the whole cap is immersed, and make sure that there is no air trapped inside the cap.

After a good, long soak, shake the cap empty over a sink. This gets messy in a hurry, so be careful.

Your next move is to hold the cap under running room-temperature water from the tap while scrubbing its insides with a small plastic-brissle brush that is like a toothbrush but smaller. Some hardware stores, tobacco shops and gun shops sell ones that work pretty well. I often use a plastic-brissle brush I found in an air rifle cleaning kit. I don’t have an air rifle to clean, but I spent the money just to get that little brush used on the air rifle barrels. Whatever you do, do not use a metal-wire brush used on regular hand guns and rifles. It will tear apart your cap.

Once the ink stops coming out of the cap in the sink, shake out the cap again. Use a Q-tip to dry out the cap. Odds are good that there is still plenty of ink in the cap, and you will go through many Q-tips trying to clean it out. You will have to keep getting Q-tips wet to keep getting the old gunk out. Pay special attention to the cap threads and the lip of the inner cap. Keep cleaning until you are satisfied.

This process takes a while, but if you only have one or two pens you have to do this for, it is worth just doing this to them once every several years. If you are a hardcore collector, we can discuss inner cap pullers and ultrasonic cleaners on another day.

Click here to see the finished restoration of the Sheaffer Lifetime cap in the photo above.

Please write in with your pen repair questions.

Parker 21, Parker 45 & Esterbrook Fountain Pens

If you have been visiting our vintage pens pages lately, you might find yourself asking, “Self, what’s with all of the cheap Parkers and Esterbrooks?”

We sell more vintage Esterbrook pens than any other brand. These copper-colored Esterbrooks are my personal favorite of the options available, but our most popular colors are blue, grey and black.

We sell more vintage Esterbrook pens than any other brand. These copper-colored Esterbrooks are my personal favorite of the options available, but our most popular colors are blue, grey and black.

It is simple enough my friends. Esterbrooks are the most popular pens we sell at ThePenMarket.com. We generally can’t keep them in stock. As for the inexpensive Parkers, we had so many expensive pens on the vintage pens pages, we thought it would be nice to offer a high-quality entry pen to the site for people just looking to get into writing with fountain pens.

But then there is one more reason.

ThePenMarket.com recently acquired an amazing collection of rarer, harder to find vintage pens dating back to the turn of the last century. We’re talking hard rubber and silver filigree fountain pens. Think Waterman 12, Waterman 52, Waterman 54 and a beautiful sterling silver Waterman 452. We’ve got Parker Duofolds and Vacs. Sheaffer Lifetimes and Balances. Maybe some Mabie Todd. Perhaps some sterling and gold no names. You’ll quiver with delight at the senior Conklin Enduras with remarkable color clarity.

We’ve got 120 classic vintage pens to catalog, restore and post for sale.

Are you salivating yet? When they arrive online would you rather they be the first things you see or have them buried under 2 dozen steel nib beauties. That’s what we thought. In the coming weeks and months, e-fist fights might breakout over the first daily opportunity to buy these glorious fountain pen wonders of yesteryear.